He had family over for the 4th and noticed sand coming out from around the main wall. The wall we shoot into is one wall of a 8' x 8' sand trap. Its really overkill for anything we would be shooting and typical of my buddy.
This shows about two years of use and after looking things over has been falling apart for at least six months. Normally this would be a solid wall of rail road ties with some old interior doors screwed over them. The doors make it easy to staple targets in place but they also tend to hide the damage to the ties.
After we started removing the ties we noticed that the sand was also moving out around one of the sides. There have been a lot of recent heavy rains and the lag screws holding the ties to the 4x4 pulled through the ties. We had to bring in my buddies toy to dig the sand out and then dig out the corner by hand so we could push the ties back into place.
Here you can see the area we had to dig out to get the lower ties on the right side back into place.
This weekend we finished up by putting the lower ties back in place. We cut one in half and placed each half on end on each side to hold the lower ties in place. I talked my buddy into leaving out the upper ties. The sand sloping across is still over a food deep at its thinnest spot at the top. Behind that there is a railroad tie, 75 yards of heavily wooded forest and a 30ft berm, I think it is more than safe.
I bought a rail road tie from Lowes to place over the top since the upper tie is now gone we had nothing to hang the AR500 plates from. Unfortunately Lowes 8' ties are apparently only 7.5' so we had to add some 4x4s to hold it in place.
I think this setup will work much better and last a lot longer, the only consumable with this is the doors and I think he has about 12 more of them. To this point we have gone through three of them in two years. The 22's and .223/5.56 don't do much damage to them, not like the rail road ties that splinter and break up.
No comments:
Post a Comment